• Tech Manual Gc 160
• Tech Manual Gc160lagha

Honda Gc160 Tech Manual - In this site is not the same as a answer manual you purchase in a photograph album amassing or download off the web. Our higher than 6,017 manuals and Ebooks is the defense why customers save coming back.If you compulsion a Honda Gc160 Tech Manual, you can download them in pdf. View and Download Honda GX160 tech manual online. GX160 Engine pdf manual download.

Hello, folks. I'm the.very. lucky owner of not ONE but TWO.wonderful. Honda GCV 160 powered devices, and both of them are a dream come true. Sarcasm Does anyone know where I can get a repair manual for this engine? The 160 on my lawnmower refuses to run correctly.

It will run fine for a few minutes from cold, but it starts to cough, sputter, backfire then die. I can run it for 30 seconds before it dies again.

I've checked the carb and it's fine. Nothing plugged, fresh gas; no varnish. My next guess is to check the timing, and I've got a good handle on how to approach that from reading posts on this forum. Is there anything else I can check, such as ignition? Thanks for all your help. I'm moving in two months and would rather try to get as much life out of this mower before I leave.

I agree with 30YT that it's probably a fuel problem as opposed to ignition. The timing would not change on a running motor. It's typically either good or bad and the things that would cause it to change on a running motor are all pretty unlikely scenarios. I have seen magnetos(ignition modules) be intermittent and the best way to check that is with a gap type tester that you leave in series with the plug and watch the spark with the engine running. When the engine begins to shut down, if the spark is going away, that's a good indicator it is the cause of the shutdown.

If it isn't, I'd make the leap of faith that the ignition is probably OK and your problem is elsewhere(most likely fuel delivery). In addition to inspecting and cleaning the carb, have you tried loosening the gas cap and running it. If the vent is plugged in the cap it will run for some period of time till the bowl is empty and then stop.

Restarting can be difficult. Finally, regarding the manual. You can get them from HelmInc.com. Honda distributes their manuals through them. Here is the link for your manual.

(I haven't seen these on line anywhere for free) Let us know how you make out. Hi all, I'm a new member from Orange County, California, USA. I need some hints for the GCV160. Mine won't start - it stopped in mid-operation.

Thought the kill switch went bad but it's OK. Changed spark plug, replaced gas. Still no start. It might be bad gas - I have never stabilized the gas, but didn't worry about it since I use it every week normally, and there is no off-season in this part of the country. I guess I need to get into the carb, etc, but would like to look at a repair manual first so I don't mess something up.

I like to repair things, but would like to know the tricks. Appreciate any help. First thing to know is that I know almost nothing about small engines. I hit a baseball while cutting the grass. The engine stalled. I started it up again, but pulling the cord was hard. After starting, a puff of white smoke came out of the exhaust.

I lifted the mower up and saw that the two blades were locked together. That wasn't how they were when I looked before. The two blades run separately, right?

Tech Manual Gc 160

Do they turn in the same direction or counter each other? Have I destroyed the gears? Should I try in dislodge the two blades from each other? First thing to know is that I know almost nothing about small engines. I hit a baseball while cutting the grass. The engine stalled. I started it up again, but pulling the cord was hard.

After starting, a puff of white smoke came out of the exhaust. I lifted the mower up and saw that the two blades were locked together. That wasn't how they were when I looked before. The two blades run separately, right?

Do they turn in the same direction or counter each other? Have I destroyed the gears?

Tech Manual Gc160lagha

Should I try in dislodge the two blades from each other?Unless you can tell that one of the blades is bent, then they are mounted together and turn together in the same direction. They do not turn independently from each other, nor in opposite directions.

This is a mulching setup that Honda uses. Hitting the baseball may have sheared the flywheel key that times the ignition spark, but it's unusual on a Honda as their key's are steel. If your mower starts up and runs alright, then the oil may have come from when you tipped the mower over to look at the blades. If you tipped the mower over with the air filter facing down, you may have contaminated the air filter with oil. If there is oil in the air filter element, you will need to replace the air filter element as they cannot be cleaned.

Precautions and Conditions of Liability Exclusion Concerning Power Products Operation Manuals After accepting the following use conditions, please download the operation manual provided through this service. Use conditions Safety precautions Safety precautions described in the operation manual issued through this service may change following modification of legal restrictions, etc. If you have any questions about the precautions described in your product's operation manual, issued through this service, please contact the shop where the product was purchased, a nearby Honda dealer, or Customer Relations Division of Honda.

Details of this service Any operation manual issued through this service may not be copied or modified in whole or in part, without the permission of Honda Motor Co., Ltd. Parts may be printed to assist in product use. Operation manuals for all Honda products are not provided through this service. If you cannot find the required operation manual, to purchase it, please contact the shop where the product was purchased, a nearby Honda dealer, or Customer Relations Division of Honda.

Please note that some products whose operation manuals are issued through this service may have been discontinued or the operation manuals themselves may have gone out of print. Contents of the operation manual Contents of operation manuals issued through this service may not be exactly applicable to your product if there have been changes in the product's specifications. In that case, please contact the shop where the product was purchased, a nearby Honda dealer, or Customer Relations Division of Honda. Other conditions Honda is not liable in case of any damage suffered from the use of or inability to use this service. Please note that this service is subject to discontinuance or change without notice.